Page 1 of 1
Mastiff hesitant runing
Posted:
Mon Aug 10, 2015 2:59 amby ericetz301
hi folks collective wisdom please.
I have a 2001 Mastiff 42 K miles, that has started running oddly, not quite miss firing but running hesitantly, easy starting and smooth tick over, I've changed the plug NGK DPR 8 BE-9, but, still the same symptoms.
any suggestions on a cure would be appreciated.
cheers Eric.
Re: Mastiff hesitant runing
Posted:
Mon Aug 10, 2015 4:12 amby den
could be the symptoms of a weak spark.Have you had the tank of and checked the condition if the connectors and earths to the coil and the ht lead,unscrew your plug cap off and check that also.
Re: Mastiff hesitant runing
Posted:
Mon Aug 10, 2015 7:35 amby DAVID THOMPSON
my traveller went flaky one day
the plus wire was loose on the coil at the wire spade
dave
Re: Mastiff hesitant runing
Posted:
Tue Aug 11, 2015 4:15 amby ericetz301
thanks guys,
I will check out what has been suggested, and post the results.
cheers Eric.
Re: Mastiff hesitant runing
Posted:
Tue Aug 11, 2015 9:30 amby duncmac
Check the choke plunger is not jamming.
Theres other posts on here with more detail, but basically
unscrew the choke cable end from the carb.
At the end of the cable is a spring and the plunger
Clean out the orifice
Clean the plunger
lube with a tiny smidgen of silicon grease
replace and check that the idle speed changes as you move the choke through its three positions (fully off, one click on?, fully on)
Other than that its fuel air and spark.
Any blows on the exhaust
any leaks in the airbox>carb>engine rubbers.
Is the air filter fully covering the air intake (check at the bottom with gloved fingers)
Any loose wiring?
Re: Mastiff hesitant runing
Posted:
Wed Aug 12, 2015 4:54 pmby breakwellmz
Do the easy stuff first-drain the float bowl.
Re: Mastiff hesitant runing
Posted:
Wed Aug 12, 2015 5:38 pmby DAVID THOMPSON
YES the float bowl is a problem on all my bikes and the truck
a lot of the time
and the big lawn mower till i started using the ethanol free gas
dave
Re: Mastiff hesitant runing
Posted:
Thu Aug 13, 2015 1:57 amby duncmac
breakwellmz wrote:Do the easy stuff first-drain the float bowl.
Quite right, the drain screws are made of cheese btw.
While your doing it you could connect a bit of clear hose up to the float bowl drain an check the fuel level in the bowl, by holding the end of the hose up.
Might indicate your floats set too high and running rich.
Re: Mastiff hesitant runing
Posted:
Tue Sep 01, 2015 7:25 amby ericetz301
hi folks,
Many thanks for all the suggestions to cure the problem, I`ve now replaced the ignition coil C/W HT cable, treated the bike to a new Iridium plug, washed the air filter & re oiled it and finally cleaned and lubed the starter plunger assy.
The bike runs a treat now
its`a shame we`re heading for the winter
cheers Eric.